应用可压缩气体动力润滑理论建立了柔性铰链超声挤压膜滑块的动、静特性系数模型，并应用数值方法对模型进行求解，获得了高频激励条件下柔性铰链气体挤压膜滑块的动、静特性系数。讨论了悬浮高度、激励振幅以及激励频率对动特性系数的影响。根据分析发现，这些参数都对挤压膜特性有着显著的影响。悬浮高度越高，挤压膜刚度和阻尼越小。激励振幅越大，挤压膜刚度和阻尼越大。而频率的影响几乎呈线性关系，频率越高，刚度和阻尼越大，挤压膜刚度和阻尼都随着频率的增加而增加，最后对这种结论进行了解释。
A complete analytical model of the static and dynamic characteristics of an ultrasonic flexible hinges squeeze film bearing is established on the basis of the compressible gas hydrodynamic lubricating theory. With the nonlinear numerical methods model is solved. Dynamic characteristics of the air ultrasonic squeeze film at specific cases are obtained, and the effects of the exciting amplitude, frequency and film thickness on dynamic characteristics are discussed. According to the results evaluated, exciting amplitude, frequency and film thickness influence the dynamic properties significantly. The dynamic characteristics increase with the increase of exciting amplitude and frequency, while the dynamic characteristics of air ultrasonic squeeze film decrease with the increase of film thickness. The effect of frequency is almost linear. The exciting frequency is higher, the stiffness and the damping is bigger. The stiffness and damping of the squeeze film increase with the increase of frequency. The reasons leading the results are presented.
[1] 徐方程,孙毅,刘占生,等. 基于箔片非线性刚度模型的气体箔片轴承静特性研究[J]. 机械工程学报,2016,52(21):56-62. XU Fangcheng, SUN Yi, LIU Zhansheng, et al. Static performance of gas foil bearings with nonlinear foil stiffness model[J]. Journal of Mechanical Engineering,2016,52(21):56-62.
[2] VANDAELE V, LAMBERT P,DELCHAMBRE A. Non-contact handling in micr-oassembly:Acoustical levitation[J]. Precision Engineering,2005,29:491-505.
[3] 马希直,王挺,王胜光. 近场超声悬浮精度的理论分析及试验研究[J]. 机械工程学报,2014,50(11):186-191. MA Xizhi,WANG Ting,WANG Shengguang. Analytical and experimental investigation on the precision of near field ultrasonic levitation[J]. Journal of Mechanical Engineering,2014,50(11):186-191.
[4] SALBU E O J. Compressible squeeze films and squeeze bearings[J]. ASME Journal of Basic Engineering,1964(6):355-366.
[5] MINIKES A,BUCHER I. Coupled dynamics of a squeeze-film levitated mass and a vibrating piezoelectric disc numerical analysis and experimental study[J]. Journal of Sound and Vibration,2003,63:241-268.
[6] TAKAAKI O,MASAYA K. Squeeze air bearing based on ultrasonic oscillation:Motion error compensation using amplitude modulation[J]. Review of Scientific Instruments,2004,75(11):4615-4620.
[7] ESMONDE H,SEE H,SWAIN M V. Modelling of ER squeeze films at low amplitude oscillations[J]. J. Non-Newtonian Fluid. Mech.,2009,161:101-108.
[8] PITEAU P,ANTUNES J. A theoretical model and experiments on the nonlinear dynamics of parallel plates subjected to laminar/turbulent squeeze-film forces[J]. Journal of Fluids and Structures,2012,33:1-18.
[9] UEHA S,HASHIMOTO Y,KOIKE Y. Non-contact transportation using near-field acoustic levitation[J]. Ultrasonics,2000,38(3):26-32.
[10] IDE T,FRIEND J,NAKAMURA K,et al. A non-contact linear bearing and actuator via ultrasonic levitation[J]. Sensors and Actuators A:Physical,2007,135(4):740-747.
[11] SU Zhao,SEBASTIAN M,WALLASCHEK J. An ultrasonic levitation journal bearing able to control spindle center position[J]. Mechanical Systems and Signal Processing,2012:1-14.
[12] GABRIELE S,GERHARD W. Physically based modeling of squeeze film damping by mixed-level system simulation[J]. Sensors and Actuators A,2002,97-98:193-200.
[13] MINHANG B,HENG Y. Squeeze film air damping in MEMS[J]. Sensors and Actuators A,2007:136:3-27.
[14] PANDEY A K,PRATAP R,CHAU F S. Analytical solution of the modified Reynolds equation for squeeze film damping in perforated MEMS structures[J]. Sensors and Actuators A:Physical,2007,135(2):839-848.
[15] VICTOR M,DIANA A B T,JOHN T. On squeeze film damping in microsystems[J]. Journal of Tribology, 2010,132(7):031701-1-6.
[16] STOLARSKI T A,WEI Chai. Self-levitating sliding air contact[J]. International Journal of Mechanical Sciences, 2006,48:601-620.
[17] YOSHIMOTO S,KOBAYASHI H,MIYATAKE M. Float characteristics of a squeeze-film air bearing for a linear motion guide using ultrasonic vibration[J]. J. of Tribology International,2007,40(3):503-511.
[18] TOMOHIRO S,SHIGEKA Y,TADEUSZ S. Running performance of an aerodynamic journal bearing with squeeze film effect[J]. International Journal of Mechanical Sciences,2013(77):184-193.
[19] 马希直,胡伟,王挺. 超声挤压膜动特性系数计算分析及影响因素研究[J]. 中国机械工程,2014,25(8):1113-1116. MA Xizhi,HU Wei,WANG Ting. Research on the dynamic characteristics of ultrasonic squeeze film and its influence factors[J]. China Mechanical Engineering,2014,25(8):1113-1116.
[20] MA Xizhi,XIE Shilong,ZHANG Wenke. Influence of the disturbance frequency on the dynamic characteristics of an ultrasonic gas squeeze film[J]. Tribology Transctions,2016,59(4):690-697.
[21] LU Jinpu,GUAN Zhi. Numerical method of partial differential equations[J]. Beijing:Tsinghua University Press,2004.
