基于负载口独立的液压式波浪能转换器捕获性能研究

刘常海, 赵志学, 胡敏, 燕浩, 杨庆俊, 包钢, 曾亿山

机械工程学报 ›› 2024, Vol. 60 ›› Issue (6) : 386-397.

PDF(29021 KB)
PDF(29021 KB)
机械工程学报 ›› 2024, Vol. 60 ›› Issue (6) : 386-397. DOI: 10.3901/JME.2024.06.386
交叉与前沿

基于负载口独立的液压式波浪能转换器捕获性能研究

  • 刘常海1,2,3, 赵志学3, 胡敏1, 燕浩1, 杨庆俊3, 包钢3, 曾亿山1
作者信息 +

Power-capture Performance of the Hydraulic-type Wave Energy Converter Based on the Individual Metering Technology

  • LIU Changhai1,2,3, ZHAO Zhixue3, HU Min1, YAN Hao1, YANG Qingjun3, BAO Gang3, ZENG Yishan1
Author information +
文章历史 +

摘要

为提高液压式波浪能转换装置的运行特性,提出一种基于负载口独立的液压式波浪能提能系统。以筏式波浪能转换装置为例,建立浮子水动力模型和非线性液压提能系统数学模型,结合实际海域波浪的特点,在不规则波下对其动力响应进行研究,探究不规则波浪参数和液压提能系统参数对装置捕获性能的影响规律。结果表明,基于负载口独立的液压式波浪能提能系统,可较大程度地提高装置的捕获性能;在同一峰值波浪周期下,有义波高越大装置的捕获宽度比越大;在同一有义波高下,随着峰值波浪周期的增大,捕获宽度比先增大后减小;随着液压缸活塞面积、液压缸铰接距离和发电机等效阻尼系数的增大,捕获宽度比增大;随着液压缸活塞杆面积与活塞面积比、液压马达排量的增大,捕获宽度比减小;高压蓄能器预充气压力对捕获宽度比几乎无影响,高压蓄能器初始体积越大,捕获宽度比略减小。

Abstract

A novel hydraulic power take-off (Power take-off system, PTO) system based on the individual metering technology is proposed to improve the performance of the hydraulic-type wave energy converters (Wave energy converters, WECs). A raft-type WEC is focused on here, and the hydrodynamic model of the floater and the nonlinear model of the hydraulic PTO system are presented. Considering the characteristics of real ocean waves, the power-capture performance of the WEC in irregular waves is discussed, and the influence of wave parameters and PTO parameter configuration on the power-capture performance is investigated. Results show that the novel hydraulic PTO system can significantly improve power-capture performance of the WEC. For a certain peak wave period, the larger the significant wave height, the higher the capture width ratio. For a certain significant wave height, the capture width ratio increases first and then decreases after reaching a peak value with increasing peak wave period. The capture width ratio increases monotonously with increasing piston area of hydraulic cylinder, mounting position of hydraulic cylinder, and effective damping of generator, while it decreases monotonously with increasing displacement of hydraulic motor and rod-to-piston area ratio of hydraulic cylinder. The pre-charge pressure of the high-pressure gas accumulator makes no difference to the capture width ratio, while larger value of initial volume of the high-pressure gas accumulator gives slightly smaller capture width ratio.

关键词

负载口独立 / 液压系统 / 波浪能 / 提能系统 / 捕获性能

Key words

individual metering / hydraulic system / wave energy / power take-off system / power-capture performance

引用本文

导出引用
刘常海, 赵志学, 胡敏, 燕浩, 杨庆俊, 包钢, 曾亿山. 基于负载口独立的液压式波浪能转换器捕获性能研究[J]. 机械工程学报, 2024, 60(6): 386-397 https://doi.org/10.3901/JME.2024.06.386
LIU Changhai, ZHAO Zhixue, HU Min, YAN Hao, YANG Qingjun, BAO Gang, ZENG Yishan. Power-capture Performance of the Hydraulic-type Wave Energy Converter Based on the Individual Metering Technology[J]. Journal of Mechanical Engineering, 2024, 60(6): 386-397 https://doi.org/10.3901/JME.2024.06.386

参考文献

[1] ZHANG Dahai,LI Wei,LIN Yonggang. Wave energy in China:Current status and perspectives[J]. Renewable Energy,2009,34(10):2089-2092.
[2] 李云飞,耿江军,汤添益,等. 面向新能源浮标的平面摆式波浪能收集装置研究[J]. 机械工程学报, 2021,57(12):275-284. LI Yunfei,GENG Jiangjun,TANG Tianyi,et al. Study on water wave energy harvester for clean energy buoys[J]. Journal of Mechanical Engineering,2021, 57(12):275-284.
[3] 丁文俊,宋保维,毛昭勇,等. 浅水域探测型无人水下航行器波浪能发电系统设计[J]. 机械工程学报,2015,51(2):141-147. DING Wenjun,SONG Baowei,MAO Zhaoyong,et al. Wave energy conversion system design for detection unmanned underwater vehicle in shallow water[J]. Journal of Mechanical Engineering,2015,51(2):141-147.
[4] 赵裕明,金振林. 基于含有冗余支链3-RPS/3-SPS并联机构的波浪能转换装置优化设计[J]. 机械工程学报,2019,55(23):93-102. ZHAO Yuming,JIN Zhenlin. Optimal design of wave power generating device based on a parallel mechanism with 3-RPS/3-SPS redundant link[J]. Journal of Mechanical Engineering,2019,55(23): 93-102.
[5] ZHANG Dahai,LI Wei,LIN Yonggang,et al. An overview of hydraulic systems in wave energy application in China[J]. Renewable and Sustainable Energy Reviews,2012,16(7):4522-4526.
[6] 盛松伟,游亚戈,张亚群,等. 漂浮式波浪能装置能量转换系统研究[J]. 机械工程学报,2012,48(24):141-146. SHENG Songwei,YOU Yage,ZHANG Yaqun,et al. Research on power take-off system of floating wave power device[J]. Journal of Mechanical Engineering, 2012,48(24):141-146.
[7] GASPAR J F,CALVARIO M,KAMARLOUEI M,et al. Power take-off concept for wave energy converters based on oil-hydraulic transformer units[J]. Renewable Energy,2016,86:1232-1246.
[8] FALCÃO A F O. Modelling and control of oscillating-body wave energy converters with hydraulic power take-off and gas accumulator[J]. Ocean Engineering,2007,34(14-15):2021-2032.
[9] JOSSET C,BABARIT A,CLEMENT A H. A wave-to-wire model of the SEAREV wave energy converter[J]. Proceedings of the Institution of Mechanical Engineers,Part M:Journal of Engineering for the Maritime Environment,2007,221:81-93.
[10] CARGO C J,PLUMMER A R,HILLIS A J,et al. Determination of optimal parameters for a hydraulic power take-off unit of a wave energy converter in regular waves[J]. Proceedings of the Institution of Mechanical Engineers,Part A:Journal of Power and Energy,2012,226(1):98-111.
[11] RICCI P,LOPEZ J,SANTOS M,et al. Control strategies for a wave energy converter connected to a hydraulic power take-off[J]. IET Renewable Power Generation,2011,5(3):234-244.
[12] YANG Limin, MOAN T. Dynamic analysis of wave energy converter by incorporating the effect of hydraulic transmission lines[J]. Ocean Engineering,2011,38(16):1849-1860.
[13] LIU Zhen,QU Na,HAN Zhi,et al. Study on energy conversion and storage system for a prototype buoys-array wave energy converter[J]. Energy for Sustainable Development,2016,34:100-110.
[14] 杨绍辉,何宏舟,陈沪,等. 阵列筏式波浪能发电系统设计与试验研究[J]. 机械工程学报,2016,52(11):57-62. YANG Shaohui,HE Hongzhou,CHEN Hu,et al. Design and experiment research on array-raft wave energy power generation system[J]. Journal of Mechanical Engineering,2016,52(11):57-62.
[15] LIN Yonggang,TU Le,ZHANG Dahai,et al. A study on dual-stroke pendulum wave energy conversion technology based on a water/oil integrated transmission system[J]. Ocean Engineering,2013,67:27-34.
[16] 叶寅,游亚戈,王振鹏,等. 波浪能装置液压自动分级控制系统研究[J]. 太阳能学报,2019,40(6):1481-1486. YE Ying,YOU Yage,WANG Zhenpeng,et al.Automic classification control system of wave energy device research[J]. Acta Energiae Solaris Sinaca,2019,40(6):1481-1486.
[17] 陈启卷,李永兴,许志翔,等. 液压传动共振波力发电装置提能系统特性研究[J]. 机械工程学报,2017,53(14):209-216. CHEN Qijuan,LI Yongxing,XU Zhixiang,et al. Research on hydraulic power take-off system of resonant wave generation device[J]. Journal of Mechanical Engineering,2017,53(14):209-216.
[18] 高红,肖杰. 基于模糊PI的波浪能液压转化系统平稳控制研究[J]. 机械工程学报,2021, 57(10):267-276. GAO Hong,XIAO Jie. Research on stabilization control of wave energy hydraulic conversion system based on fuzzy-PI[J]. Journal of Mechanical Engineering,2021,57(10):267-276.
[19] 高红,梁睿智. 波浪能捕获液压系统的特性研究[J]. 机械工程学报,2020,56(18):180-187. GAO Hong,LIANG Ruizhi. Performance investigation of hydraulic wave energy capture system[J]. Journal of Mechanical Engineering,2020,56(18):180-187.
[20] 吴金明,陈妮,钱晨. 惯性式波浪能供电浮标的液压能量转换系统设计研究[J]. 机械工程学报,2022,58(4):222-231. WU Jinming,CHEN Ni,QIAN Chen. Research on design method of the hydraulic energy conversion system of an inertial wave-energy-powered buoy[J]. Journal of Mechanical Engineering,2022,58(4):222-231.
[21] 曹剑,徐兵,杨华勇,等. 负载口独立控制系统静态工作点选取原则及仿真分析[J]. 机械工程学报,2006,4(6):11-15. CAO Jiang,XU Bing,YANG Huayong,et al. Principles for choosing static operation points and simulation analysis of fluid power system based on separate control of actuator ports[J]. Journal of Mechanical Engineering,2006,4(6):11-15.
[22] 董致新,黄伟男,葛磊,等. 泵阀复合进出口独立控制液压挖掘机特性研究[J]. 机械工程学报,2016,52(12):173-180. DONG Zhixin,HUANG Weinan,GE Lei,et al. Research on the performance of hydraulic excavator with pump and valve combined separate meter in and meter out circuits[J]. Journal of Mechanical Engineering,2016,52(12):173-180.
[23] 王涛,刘毅,黄方平,等. 负载口独立控制双联阀建模与特性分析[J]. 液压与气动,2019(10):11-19. WANG Tao,LIU Yi,HUANG Fangping,et al. Modeling and characteristic analysis of independent metering control twin-value[J]. Chinese Hydraulics & Pneumatics,2019(10):11-19.
[24] 牛善帅,王军政,张鹏,等. 基于负载口独立控制的双伺服阀控缸系统[J]. 北京理工大学学报,2019,39(12):1292-1297. NIU Shanshuai,WANG Junzheng,ZHANG Peng,et al. Separate meter in and meter out valve controlled cylinder system based on dual servo control[J]. Transactions of Beijing Institute of Technology,2019,39(12):1292-1297.
[25] 曹晓明,姚静,沙桐,等. 多级压力源切换负载口独立控制系统能耗特性实验研究[J]. 西安交通大学学报,2019,53(12):63-71. CAO Xiongming,YAO Jing,SHA Tong,et al. Experimental research on energy consumption characteristics for multi-level pressure switching control system based on independent metering control[J]. Journal of Xi’an Jiaotong University,2019,53(12):63-71.
[26] 陈晖,施承伟,杜恒,等. 负载口独立控制系统的节能边界[J]. 液压与气动,2021,(2):63-70. CHEN Hui,SHI Chengwei,DU Heng,et al. Energy saving boundary of the independent metering system[J]. Chinese Hydraulics & Pneumatics,2021,(2):63-70.
[27] 丁孺琦,徐兵,张军辉,等. 负载口独立控制系统压力速度复合控制的耦合特性[J]. 浙江大学学报(工学版),2017,51(6):1126-1134. DING Ruqi,XU Bing,ZHANG Junhui,et al. Coupling characteristics of pressure and speed compound control of load port independent control system[J]. Journal of Zhejiang University (Engineering Science Edition),2017,51(6):1126-1134.
[28] 丁孺琦,江来,李刚,等. 电液负载敏感负载口独立多模式切换控制能效研究[J]. 农业机械学报,2021,52(12):433-442. DING Ruqi,JIANG Lai,LI Gang,et al. Energy efficiency of electro-hydraulic load sensing independent metering multi-mode switching control system[J]. Transactions of the Chinese Society for Agricultural Machinery,2021,52(12):433-442.
[29] 曾亿山,黄河,刘常海,等. 基于回油补偿的负载口独立系统节能特性分析[J]. 机床与液压,2022,50(13):1-6. ZENG Yishan,HUANG He,LIU Changhai,et al. Energy saving analysis of the independent metering system based on pressure compensated method in the offside[J]. Machine Tool & Hydraulics,2022,50(13):1-6.
[30] 訚耀保. 海洋波浪能综合利用:发电原理与装置[M]. 上海:上海科学技术出版社,2013. YIN Yaobao. Principle and device of the ocean wave energy conversion generation[M]. Shanghai:Shanghai Science and Technology Press,2013.
[31] LIU Changhai,YANG Qjingjun,BAO Gang. Performance investigation of a two-raft-type wave energy converter with hydraulic power take-off unit[J]. Applied Ocean Research,2017,62:139-155.
[32] FALNES J. Ocean waves and oscillating systems: linear interaction including wave energy extraction[M]. Cambridge:Cambridge University Press,2002.
[33] BABARIT A,HALS J,MULIAWAN M J,et al. Numerical benchmarking study of a selection of wave energy converters[J]. Renewable Energy,2012,41: 44-63.
[34] 刘常海,胡敏,杨庆俊,等. 波浪能发电半物理仿真试验技术研究[J]. 机械工程学报,2021,57(10):286-296. LIU Changhai,HU Min,YANG Qingjun,et al. Hardware-in-the-loop simulation technology of wave power generation[J]. Journal of Mechanical Engineering,2021,57(10):286-296.
PDF(29021 KB)

44

Accesses

0

Citation

Detail

段落导航
相关文章

/