针对一台14对极21个调磁极片的调磁式异步磁力联轴器,为研究其气隙中永磁磁场与调制磁场的空间分布规律,利用有限元模拟的方法,得出静态与瞬态下三维气隙磁场的分布及周期性;基于等效面电流法,采用Matlab软件进行离散化编程求解,得到外气隙永磁磁场沿径向、周向及轴向的三维空间分布及周期性;采用多维高精度数字化测磁装置对联轴器的永磁磁场及调制磁场进行两种不同方案的三维测量。结果表明,永磁磁场与调制磁场均呈现周期性分布,其周期数分别为14、7;瞬态下气隙磁场的磁感应强度幅值大于静态时的幅值;气隙磁场存在端部效应,气隙磁场径向与周向分量的端部磁场小于中间磁场,轴向分量则相反;测量结果与模拟结果、解析结果具有很好的一致性。
A field modulated asynchronous magnetic coupling with 14 pole pairs and 21 ferromagnetic pole-pieces is researched to obtain the spatial distributions of the permanent magnetic field and the modulated magnetic field in the air-gap. The distributions and periods of three-dimensional air-gap magnetic fields are obtained by finite element simulation under the static and transient conditions. Based on equivalent surface current method, the three-dimensional spatial distributions and periods of the permanent field including radial, circumferential and axial components in the outer air-gap are obtained by using the discrete programming of Matlab software. The three-dimensional air-gap fields including the permanent magnetic field and the modulated magnetic field are measured through two different schemes by high precision 3D magnetic field measuring devices. The results show that the distributions of the permanent magnetic field and the modulated magnetic field are periodic, and the number of periods are 14 and 7 respectively. The magnitude of the air-gap magnetic flux density under transient condition is larger than that under static condition. Air-gap magnetic fields’ end effect exist, so that the end region magnetic fields of radial and circumferential components are less than the middle region magnetic fields, but the axial component is the opposite. All of the measurement results, the simulation results and the analytical results are in good agreement.
[1] 赵克中. 磁力驱动技术与设备[M]. 北京：化学工业出版社,2004.
ZHAO Kezhong. Magnetic driving technology and equipment[M]. Beijing：Chemical Industry Press, 2004.
[2] 杨超君,管春松,丁磊,等. 盘式异步磁力联轴器传动特性[J]. 机械工程学报,2014,50(1)：76-84.
YANG Chaojun, GUAN Chunsong, DING Lei, et al. Transmission characteristics of axial asynchronous permanent magnet couplings[J]. Journal of MechanicalEngineering, 2014, 50(1)：76-84.
[3] ATALLAH K, HOWE D. A novel high-performance magnetic gear[J]. Magnetics, IEEE Transactions on, 2001, 37(4)：2844-2846.
[4] WANG Lili, SHEN Jianxin, LUK P C K, et al. Development of a magnetic-geared permanent-magnet brushless motor[J]. Magnetics, IEEE Transactions on, 2009, 45(10)：4578-4581.
[5] ATALLAH K, RENS J, MEZANI S, et al. A novel “pseudo” direct-drive brushless permanent magnet machine[J]. Magnetics, IEEE Transactions on, 2008, 44(11)：4349-4352.
[6] 杨超君,蒋毅一. 耐高温高性能斜槽式转子异步磁力联轴器：中国,ZL200910024449.0[P]. 2011-08-10.
YANG Chaojun, JIANG Yiyi. Skewed rotor asynchronous magnetic coupling with high temperature resistance and high performance：China, ZL200910024449.0 [P]. 2011-08-10.
[7] YANG Chaojun, ZHOU Yuehua, CHEN Xiaoping, et al. Electromagnetic properties analysis of field-modulated asynchronous magnetic couplings[J]. Applied Mechanic and Materials, 2014, 535：192-197.
[8] YANG Chaojun, LU Dan, HU You, et al. Magnetic-field modulation principle and transmission ratio calculation of field-modulated asynchronous magnetic coupling[J]. Applied Mechanic and Materials, 2014, 535：48-52.
[9] RASMUSSEN P O, ANDERSEN T O, JONGENSENF T, et al. Development of a high-performance magnetic gear[J]. IEEE Transactions on Industry Applications, 2005, 41(3)：764-770.
[10] 杨超君,李直腾,李志宝,等. 高性能磁力齿轮传动扭矩与效率的数值计算[J]. 中国电机工程学报,2011,31(32)：107-114.
YANG Chaojun, LI Zhiteng, LI Zhibao, et al. Numerical calculation of driven torque and efficiency of a high-performance magnetic gear[J]. Proceedings of the CSEE, 2011, 31(32)：107-114.
[11] 杨超君,李志宝,周曰华. 磁力齿轮中调磁极片结构参数的数值模拟分析[J]. 江苏大学学报,2014,35(1)：80-86.
YANG Chaojun, LI Zhibao, ZHOU Yuehua, et al. Numerical simulation and analysis of structural parameters of ferromagnetic pole pieces in magnetic gears[J]. Journal of Jiangsu University, 2014, 35(1)：80-86.
[12] 顾红伟. 深槽式鼠笼转子异步磁力联轴器电磁场分析与计算[D]. 镇江：江苏大学,2008.
GU Hongwei. Analysis and calculation of electromagnetic field in deep slot squirrel cage rotor asynchronous magnetic coupling[D]. Zhenjiang：Jiangsu University,
13 2008.
[13] 杨通. 笼型实心转子屏蔽电机电磁场有限元分析与计算[D]. 武汉：华中科技大学,2006.
YANG Tong. Analysis and calculation of a canned motor with solid and cage rotor by finite element method[D]. Wuhan：Huazhong University of Science and Technology, 2006.
[14] 赵博,张洪亮,陈洪军, 等. Ansoft 12在工程电磁场中的应用[M]. 北京：中国水利水电出版社,2010.
ZHAO Bo, ZHANG Hongliang, CHEN Hongjun, et al. The application of Ansoft 12 in engineering electromagnetic field[M]. Beijing：China Water&Power Press, 2006.
[15] 唐任远．现代永磁电机的理论与设计[M]. 北京：机械工业出版社,1997．
TANG Renyuan. The theory and design of modern permanent magnet motor[M]. Beijing：China Machine Press, 1997.
[16] 冯慈章,马西奎. 工程电磁场导论[M]. 北京：高等教育出版社,2000.
FENG Cizhang, MA Xikui. An introduction to engineering electromagnetic fields[M]. Beijing：Higher Education Press, 2000.
[17] 花为,程明,朱孝勇,等. 端部效应对新型定子永磁型双凸极电机反电势的影响研究[J]. 中国电机工程学报,2007,27(24)：63-67.
HUA Wei, CHENG Ming, ZHU Xiaoyong, et al. Investigation of end-effect in novel doubly-salient machines with PM in stator[J]. Proceedings of the CSEE, 2007, 27(24)：63-67.
