机械工程学报 >

2017 , Vol. 53 >Issue 20: 161 - 168

DOI: https://doi.org/10.3901/JME.2017.20.161

交叉与前沿

低含气率气液两相流涡街特性研究

  • 李金霞 ,
  • 王超 ,
  • 丁红兵
展开
  • 1. 天津大学电气自动化与信息工程学院 天津 300072;
    2. 天津大学天津市过程检测与控制重点实验室 天津 300072
李金霞,女,1988年出生,博士研究生.主要研究方向为涡街与气液两相流.E-mail:lijinxia@tju.edu.cn;丁红兵,男,1987年出生,博士,讲师.主要研究方向为正压法声速喷嘴气体流量标准装置.E-mail:hbding@tju.edu.cn

收稿日期: 2016-09-02

  修回日期: 2017-03-09

  网络出版日期: 2017-10-20

基金资助

国家自然科学基金（51506148）和天津市自然科学基金（16JCQNJC03700，15JCYBJC19200）资助项目。

收起

Vortex Street Characteristics of Two-phase Flow with Low Gas Fraction

  • LI Jinxia ,
  • WANG Chao ,
  • DING Hongbing
Expand
  • 1. School of Electrical and Information Engineering, Tianjin University, Tianjin 300072;
    2. Tianjin Key Laboratory of Process Measurement and Control, Tianjin University, Tianjin 300072

Received date: 2016-09-02

  Revised date: 2017-03-09

  Online published: 2017-10-20

Fold

摘要

气液两相涡街现象广泛存在于生产实际中，由于相间作用，研究变得较为复杂。通过数值模拟和实流试验，对水平管低含气率情况下气相对两相涡街的影响进行研究。建立三维计算流体力学（Computational fluid dynamics， CFD）仿真模型，采用VOF多相流模型和RNG k-e 湍流模型，模拟气液两相钝体绕流。仿真与试验结果在定量频率上具有良好的一致性。结合仿真与试验结果，从近尾迹流场与涡拓扑、斯特劳哈尔数两方面，对不同含气率两相涡街特性进行对比研究。结果表明，在稳定涡街范围内，随着气相含率增大，对涡街起重要作用的滞止区长度增大，导致斯特劳哈尔数线性减小；同时，涡街周期性和信号质量变差，涡街能量降低，这是由于涡中心吸入密度小、速度大的气泡，造成涡的旋转能量降低，进而影响涡街的稳定性。

关键词： 气液两相流; 涡街; 斯特劳哈尔数; CFD; 涡拓扑; 气相影响

本文引用格式

李金霞 , 王超 , 丁红兵 . 低含气率气液两相流涡街特性研究[J]. 机械工程学报, 2017 , 53(20) : 161 -168 . DOI: 10.3901/JME.2017.20.161

Abstract

Gas-liquid two-phase vortex street widely exists in productions, which is rather complicated due to the complex phase-interactions. Numerical simulations and real flow experiments are carried out to study the gas effects to two-phase vortex street in low gas fraction of horizontal pipeline. A 3-D computational fluid dynamics(CFD) modeling is carried out to simulate the gas-liquid two-phase flow around a bluff body using a volume of fluid (VOF) mutli-phase model and RNG k-e turbulence model. The simulation results indicate a good consistency with experiments in the quantitative frequency. Combined with simulation and experimental results, the two-phase vortex street characteristics of different gas fractions are studied from the near wake flow field and vortex topology, the Strouhal number two perspectives. The results indicate that under stable vortex street, the dominant length of stagnant region increases with gas fraction, which leads to the linear decrease of Strouhal number; Meanwhile, the periodicity and signal quality of vortex street deteriorate, and the energy of vortex street reduces, this is because the air bubbles of small density and high speed are trapped by vortex core, which results in the reduction of vortex rotational energy, and further influences the stability of vortex street.

Key words： gas-liquid two-phase flow; vortex street; Strouhal number; CFD; vortex topology; gas effect

参考文献

[1] 庞立军,吕桂萍,钟苏,等. 水轮机固定导叶的涡街模拟与振动分析[J]. 机械工程学报,2011,47(22):159-166. PANG Lijun,LÜ Guiping,ZHONG Su,et al. Vortex shedding simulation and vibration analysis of stay vanes of hydraulic turbine[J]. Journal of Mechanical Engineering,2011,47(22):159-166.
[2] 彭杰纲,傅新,陈鹰. 双钝体涡街流量计流体振动特性的试验研究[J]. 机械工程学报,2002,38(8):23-26. PENG Jiegang,FU Xin,CHEN Ying. Experimental study of fluid oscillation for duai bluff body vortex flowmeter[J]. Chinese Journal of Mechanical Engineering,2002,38(8):23-26.
[3] 孙宏军,刘中杰,王林芳,等. 低含液率气液两相流涡街探头最佳安装位置研究[J]. 机械工程学报,2014,50(4):167-171. SUN Hongjun,LIU Zhongjie,WANG Linfang,et al,Research on the installation location of the vortex probe for gas-liquid two-phase flow with low liquid fraction[J]. Journal of Mechanical Engineering,2014,50(4):167-171.
[4] ZHANG Hongjian,HUANG Yongmei,SUN Zhiqiang. A study of mass flow rate measurement based on the vortex shedding principle[J]. Flow Measurement and Instrumentation,2006,17(1):29-38.
[5] JIA Yunfei,ZHANG Tao,KONG Deren. Experiment of vortex flowmeter used in gas-liquid measurement[J]. Journal of Nanjing University of Science and Technology,2010,34(1):103-107.
[6] KHALEDI H A,ANDERSSON H I. On vortex shedding from a hexagonal cylinder[J]. Physics Letters A,2011,375(45):4007-4021.
[7] OUDHEUSDEN B W V,SCARANO F,HINSBERG N P V,et al. Phase-resolved characterization of vortex shedding in the near wake of a square-section cylinder at incidence[J]. Experiments in Fluids,2005,39(1):86-98.
[8] ALEKSEENKO S V,KUIBIN P A,OKULOV V L. Vortex precession in a gas–liquid flow[J]. Heat Transfer Research,2010,41(4):465-477.
[9] SUN H,LI J,WANG C,et al. Numerical simulation and experimental study of the vortex flow around a bluff body in horizontal gas-liquid two-phase flow[C]//International Instrumentation and Measurement Technology Conference,May 12-15,2014,Montevideo,Uruguay,IEEE,2014:272-275.
[10] 林宗虎,李永光,卢家才,等. 气液两相流旋涡脱落特性及与工程应用[M]. 北京:化学工业出版社,2001. LIN Zonghu,LI Yongguan,LU Jiacai,et al. Vortex shedding characteristics of gas-liquid two-phase flow and its engineering application[M]. Beijing:Chemical Industry Press,2001.
[11] 孙志强. 基于涡街特性的流动分析与参数检测[D]. 杭州:浙江大学,2007. SUN Zhiqiang. Analysis and measurement of fluid flow using the characteristics of vortex street[D]. Hangzhou:Zhejiang University,2007.
[12] HULIN J,FIERFORT R,COUDOL C. Experimental study of vortex emission behind bluff obstacles in a gas liquid vertical two-phase flow[J]. International Journal of Multiphase Flow,1982,8(5):475-490.
[13] GHORAI S,NIGAM K D P. CFD modeling of flow profiles and interfacial phenomena in two-phase flow in pipes[J]. Chemical Engineering and Processing,2006,45(1):55-65.
[14] VENUGOPAL A,AGRAWAL A,PRABHU S V. Influence of blockage and shape of a bluff body on the performance of vortex flowmeter with wall pressure measurement[J]. Measurement,2011,44(5):954-964.
[15] ZHENG Dandan,ZHANG Tao. An experimental study of position of piezoelectric probe in vortex flow sensor[J]. Acta Metrologica Sinica,2008,29(5):427-433.
[16] MIAU J J,WU C W,HU C C,et al. A study on signal quality of a vortex flowmeter downstream of two elbows out-of-plane[J]. Flow Measurement & Instrumentation,2002,13(3):75-85.
[17] HIRT C W,NICHOLS B D. Volume of fluid(VOF) method for the dynamics of free boundaries[J]. Journal of Computational Physics,1981,39(1):201-225.
[18] BRACKBILL J U,KOTHE D B,ZEMACH C A. A continum method for modeling surface tension[J]. Journal of Computational Physics,1992,100(2):335-354.
[19] YOUNGS D L. Numerical methods for fluid dynamics[M]. New York:Academic Press,1982.
[20] ISSA R I. Solution of the implicitly discretized fluid flow equations by operator splitting[J]. Journal of Computational Physics,1986,62(1):40-65.
[21] VERSTEEG H K,MALALASEKERA W. An introduction to computational fluid dynamics,the finite volume method[M]. Harlow,Essex:Longman Scientific and Technical,1995.
[22] ORSZAG A,YAKHOT V,FLANNERY W S, et al. Renormalization group modeling and turbulence simulations[C/CD]//International Conference on Near Wall Turbulent Flows,Tempe,Arizona,1993.
[23] PANKANIN G. What is the role of the stagnation region in Karman vortex shedding[J]. Metrology and Measurement Systems,2011,18(3):361-370.
[24] 王建文,刘俊,安琦. 一种基于图像分析的润滑油含气率测量方法[J]. 机械工程学报,2009,45(6):309-312. WANG Jianwen, LIU Jun,AN Qi. Method of measuring void fraction in lubricating oil based on image processing[J]. Journal of Mechanical Engineering,2009,45(6):309-312.
[25] 于培宁,徐英,张涛,等. 基于截面气含率的文丘里湿气压降模型[J]. 化工学报,2014,65(12):4692-4698. YU Peining,XU Ying,ZHANG Tao,et al. Modeling of wet-gas flow through horizontal Venturi based on void fraction[J]. Journal of Chemical Industry and Engineering,2014,65(12):4692-4698.
[26] ARMAND A A. The resistance during the movement of a two-phase system in horizontal pipes[R]. Atomic Energy Research Establishment,1959.
[27] 林宗虎,王数众,王栋. 气液两相流和沸腾传热[M]. 西安:西安交通大学出版社,2003. LIN Zonghu,WANG Shuzhong,WANG Dong. Gas-liquid two-phase flow and boiling heat transfer[M]. Xi'an:Xi'an Jiaotong University Press,2003.
[28] ZUBER N,FINDLAY J A. Average volumetric concentration in two phase flow systems[J]. Journal of Heat Transfer,1965,87(4):453-468.
[29] HIBIKI T,ISHⅡ M. One-dimensional drift-flux model and constitutive equations for relative motion between phases in various two-phase flow regimes[J]. International Journal of Heat and Mass Transfer,2003,46(25):4935-4948.
[30] BIRKHOFF G. Formation of vortex street[J]. Journal of Applied Physics,1953,24(1):98-103.
[31] FUNAKAWA M. The Vibration of a cylinder caused by wake force in a flow[J]. The Japan Society of Mechanical Engineers,1969,12(53):1003-1010.
Options
文章导航

/

〈 〉

版权所有 © 《机械工程学报》编辑部

技术支持：北京玛格泰克科技发展有限公司