机械工程学报 >

2017 , Vol. 53 >Issue 21: 86 - 94

DOI: https://doi.org/10.3901/JME.2017.21.086

摩擦学

典型构筑植物表面不同湿度条件下黏附和摩擦特性研究

  • 王玉娟 ,
  • 宋小闯 ,
  • 杨决宽 ,
  • 毕可东 ,
  • 陈云飞
展开
  • 1. 东南大学机械工程学院 南京 211189;
    2. 东南大学江苏省微纳生物医疗器械设计与制造重点实验室 南京 211189

收稿日期: 2016-11-11

  修回日期: 2017-06-22

  网络出版日期: 2017-11-05

基金资助

国家自然科学基金资助项目（51345012）。

收起

Adhesion and Friction Properties of Plant Surfaces with Typical Architectures in Different Humidity Conditions

  • WANG Yujuan ,
  • SONG Xiaochuang ,
  • YANG Juekuan ,
  • BI Kedong ,
  • CHEN Yunfei
Expand
  • 1. School of Mechanical Engineering, Southeast University, Nanjing 211189;
    2. Jiangsu Key Laboratory for Design and Manufacture of Micro-nano Biomedical Instruments, Southeast University, Nanjing 211189

Received date: 2016-11-11

  Revised date: 2017-06-22

  Online published: 2017-11-05

Fold

摘要

利用原子力显微镜的胶体探针技术，对不同湿度条件下四种具有典型构筑（光滑二维蜡质层、微褶皱、大褶皱、三维蜡质晶体）的原始植物表面以及两种氯仿处理后的植物样品表面的黏附力和摩擦力进行定量测试和分析。试验结果表明：冬青叶表面光滑二维蜡质涂层降低了其表面能和亲水特性，这不仅降低胶体探针与其表面在干燥条件下固固接触的摩擦力和黏附力，而且有效地阻碍了小湿度条件下液桥的形成，提高了其在小湿度条件下的脱附性能；荔枝叶表面微褶皱结构特征增大了固固接触的缝隙，不利于空气中的水蒸气冷凝并在毛细力的作用下形成液桥，从而在更大的湿度范围内提高了其脱附能力，脱附效果优于二维蜡质涂层；仙客来表面大褶皱特征和猪笼草表面三维蜡质晶体能有效排除接触界面附近的水蒸气，在干燥条件和高湿度条件下均能保持高效脱附功能，而猪笼草表面的微结构特征和蜡质晶体低表面能的耦合作用使其具有比仙客来表面大褶皱结构特征更优良的脱附功能。这些研究成果为仿生反黏附表面的设计和制备提供了理论依据。

关键词： 胶体探针; 湿度; 黏附力; 摩擦力; 典型构筑

本文引用格式

王玉娟 , 宋小闯 , 杨决宽 , 毕可东 , 陈云飞 . 典型构筑植物表面不同湿度条件下黏附和摩擦特性研究[J]. 机械工程学报, 2017 , 53(21) : 86 -94 . DOI: 10.3901/JME.2017.21.086

Abstract

Colloidal probes, based on the high precision of atomic force microscope (AFM), are employed to measure the adhesion and friction of original plant surfaces characterized with four typical architectures (smooth two-dimensional wax layers, low cuticular folds, high cuticular folds, three-dimensional wax crystals) and two plant surfaces exposed to chloroform in dry and various humidity environments. The results show that the surface energy and hydrophilicity of holly leaves are reduced by their smooth two-dimensional wax layers, which could not only lower the friction and adhesion between the colloidal probe and plant surfaces under dry conditions, but also prevent the formation of capillary bridges in ambient air with a low humidity, thus enhancing the desorption capability. The surface structure of Litchi leaves with low cuticular folds increases the gap between two interactive surfaces, against the formation of capillary bridges by the vapor condensation. As a consequence, the anti-adhesion performance of their surfaces is improved and better than that of two-dimensional wax layers in a wide range of humidity conditions. Water vapor around contact areas is excluded by cyclamen persicum leaves with high cuticular folds and nepenthes surfaces with three-dimensional wax crystals, making them possess a strong anti-adhesion capacity either in dry or high humidity ambient air. The coupling of three-dimensional architecture and wax crystals with low surface energy keeps the slippery surface of nepenthes presenting a better anti-adhesion effect than that of cyclamen persicum leaves with high cuticular folds. The results above provide a theoretical foundation for the design and preparation of bionic anti-adhesion surfaces.

Key words： colloidal probe; humidity; adhesion; friction; typical architecture

参考文献

[1] GENZER J, EFIMENKO K. Recent developments in superhydrophobic surface and their relevance to marine fouling:a review[J]. Biofouling, 2006, 22(5):339-360.
[2] KERSTIN K, BHARAT B, WIKHELM B. Diversity of structure, morphology and wetting of plant surface[J]. Soft Matter, 2008, 4(10):1943-1963.
[3] 邱宇辰,刘克松,江雷. 花生叶表面的高黏附超疏水特性研究及其仿生制备[J]. 中国科学:化学, 2011, 41(2):403-408. QIU Yuchen, LIU Kejiang, JIANG Lei. High adhesion super-hydrophobic properties of peanut leaf surface and its biomimetic synthesis[J]. Science China, 2011, 41(2):403-408.
[4] YAO J, WANG J N, YU Y H, et al. Biomimetic fabrication and characterization of an artificial rice leaf surface with anisotropic wetting[J]. Chinese Science Bulletin, 2012, 57(20):2631-2634.
[5] 刘克松,江雷. 仿生结构及其功能材料研究进展[J]. 科学通报, 2009, 54(18):2667-2681. LIU Kejiang, JIANG Lei. Research progress of bionic structure and its function materials[J]. Chinese Science Bulletin, 2009, 54(18):2667-2681.
[6] WANG G, GUO Z, LIU W. Interfacial effects of superhydrophobic plant surfaces:A review[J]. Journal of Bionic Engineering, 2014, 11(3):325-345.
[7] BAEK S H, PARK J, KIM D M, et al. Giant piezoelectricity on Si for hyperactive MEMS[J]. Science, 2011, 334(6058):958-961.
[8] BIFANO T. Adaptive imaging:MEMS deformable mirrors[J]. Nature photonics, 2011, 5(1):21-23.
[9] 钱林茂,田煜,温诗铸. 纳米摩擦学[M]. 北京:科学出版社, 2013:339-339. QIAN Linmao, TIAN Yu, WEN Shizhu. Nano-tribology[M]. Beijing:Science Press, 2013:339-339
[10] PRÜM B, SEIDEL R, BOHN H F, et al. Plant surfaces with cuticular folds are slippery for beetles[J]. Journal of the Royal Society, Interface/the Royal Society, 2012, 9(66):127-135.
[11] PRÜM B, BOHN H F, SEIDEL R, et al. Plant surfaces with cuticular folds and their replicas:Influence of microstructuring and surface chemistry on the attachment of a leaf beetle[J]. Acta Biomaterialia, 2013, 9(5):6360-6368.
[12] GORB E, HASS K, HENRICH A, et al. Composite structure of the crystalline epicuticular wax layer of the slippery zone in the pitchers of the carnivorous plant Nepenthes alata and its effect on insect attachment[J]. Journal of Experimental Biology, 2005, 208(24):4651-4662.
[13] BENZ M J, GORB E V, GORB E N. Diversity of the slippery zone microstructure in pitchers of nine carnivorous Nepenthes taxa[J]. Arthropod-Plant Interactions, 2012, 6(1):147-158.
[14] BAUER U, SCHARMANN M, SKEPPER J, et al. 'Insect aquaplaning'on a superhydrophilic hairy surface:How Heliamphora nutans Benth. pitcher plants capture prey[J]. Proceedings of the Royal Society B:Biological Sciences, 2013, 280(1753):20122569.
[15] FEDERLE W, RIEHLE M, CURTIS A S G, et al. An integrative study of insect adhesion:Mechanics and wet adhesion of pretarsal pads in ants[J]. Integrative and Comparative Biology, 2002, 42(6):1100-1106.
[16] WHITNEY H M, FEDERLE W. Biomechanics of plant-insect interactions[J]. Current Opinion in Plant Biology, 2013, 16(1):105-111.
[17] QIAN J, GAO H. Scaling effects of wet adhesion in biological attachment systems[J]. Acta Biomaterialia, 2006, 2(1):51-58.
[18] LABONTE D, FEDERLE W. Scaling and biomechanics of surface attachment in climbing animals[J]. Philosophical Transactions of the Royal Society of London B:Biological Sciences, 2015, 370(1661):20140027.
[19] GORB E V, PURTOV J, GORB S N. Adhesion force measurements on the two wax layers of the waxy zone in Nepenthes alata pitchers[J]. Scientific reports, 2014, 4:5154.
[20] GAN Y. Attaching spheres to Cantilevers for colloidal probe force measurements:A simplified techniques[J]. Microscope Today, 2005, 13(6):48-50.
[21] PRÜM B, SEIDEL R, BOHN H F, et al. Impact of cell shape in hierarchically structured plant surfaces on the attachment of male Colorado potato beetles (Leptinotarsa decemlineata)[J]. Beilstein Journal of Nanotechnology, 2012, 3(1):57-64.
[22] 温诗铸,黄平. 界面科学与技术[M]. 北京:清华大学出版社, 2011. WEN Shizhu, HUANG Ping. Interface science and technology[M]. Beijing:Tsinghua University Press, 2011.
[23] DZYALOSHINSKⅡ I E, LIFSCHITZ E M, PITAEVSKⅡ L P. General theory of van der Waals'force[J]. Sov. Phys. Usp, 1961, 4(6):153-176.
[24] POPOV V L. Contact mechanics and friction physical principles and applications[M]. German:Springer, 2009.
[25] JOHNSON K L, KENDALL K, ROBERTS A D. Surfaces energy and contact of elatic solids[J]. Proceedings of the Royal Society of London Series A-Mathematical and Physical Science, 1971, 324(1558):301-309.
[26] BULLOCK J M R, FEDERLE W. The effect of surface roughness on claw and adhesive hair performance in the dock beetle Gastrophysa viridula[J]. Insect Science, 2011, 18(3):298-304.
[27] GORB E, VOIGT D, EIGENBRODE S D, et al. Attachment force of the beetle cryptolaemus montrouzieri (coleoptera, coccinellidae) on leaflet surfaces of mutants of the pea pisum sativum (fabaceae) with regular and reduced wax coverage[J]. Arthropod-Plant Interactions, 2008, 2(4):247-259.
[28] VOIGT D, SCHUPPERT J M, DATTINGER S, et al. Sexual dimorphism in the attachment ability of the colorado potato beetle leptinotarsa decemlineata (coleopterachrysomelidae) to rough substrates[J]. Journal of Insect Physiology, 2008, 54(5):765-776.
[29] VOIGT D, SCHWEIKART A, FERY A, et al. Leaf beetle attachment on wrinkles:Isotropic friction on anisotropic surfaces[J]. The Journal of Experimental Biology, 2012, 215(11):1975-1982.
[30] SCHOLZ I, BÜCKINS M, DOLGE L, et al. Slippery surfaces of pitcher plants:Nepenthes wax crystals minimize insect attachment via microscopic surface roughness[J]. The Journal of Experimental Biology, 2010, 213(7):1115-1125.
[31] 毕可东,宋小闯,王玉娟,等. 猪笼草蜡质滑移区表面反黏附特性的研究[J]. 机械工程学报, 2015, 51(23):103-109. BI Kedong, SONG Xiaochuang, WANG Yujuan, et al. Anti-adhension mechanisms of nepenthes waxy slippery zone surface[J]. Journal of Mechanical Engineering, 2015, 51(23):103-109.
[32] WEI Z, ZHAO Y P. Growth of liquid bridge in AFM[J]. Journal of Physics D:Applied Physics, 2007, 40(14):4368-4375.
[33] BHUSHAN B. Adhesion and stiction:Mechanisms, measurement techniques, and methods for reduction[J]. Journal of Vacuum Science & Technology B, 2003, 21(6):2262-2296.
[34] BINGGELI M, MATE C M. Influence of capillary condensation of water on nanotribology studied by force microscopy[J]. Applied Physics Letters, 1994, 65(4):415-417.
[35] WANG L, RÉGNIER S. Capillary force between a probe tip with a power-law profile and a surface or a nanoparticle[J]. Modelling and Simulation in Materials Science and Engineering, 2015, 23(1):015001.
Options
文章导航

/

〈 〉

版权所有 © 《机械工程学报》编辑部

技术支持：北京玛格泰克科技发展有限公司