研究论文

高速保护气流向对光纤激光深熔焊接羽辉的影响

  • 孔华 ,
  • 杨武雄 ,
  • 邹江林 ,
  • 赵振家
展开
  • 北京工业大学, 高功率及超快激光先进制造实验室, 北京, 100124
孔华,硕士;主要研究方向为激光先进制造;Email: kongh@emails.bjut.edu.cn

收稿日期: 2022-09-20

  网络出版日期: 2024-01-16

基金资助

国家自然科学基金面上项目(51875007);北京市自然科学基金面上项目(3222004).

Influence of flow direction of high-speed shielding gas on plume in fiber laser deep penetration welding

  • KONG Hua ,
  • YANG Wuxiong ,
  • ZOU Jianglin ,
  • ZHAO Zhenjia
Expand
  • High-Power and Ultrafast Laser Manufacturing Laboratory, Beijing University of Technology, Beijing, 100124, China

Received date: 2022-09-20

  Online published: 2024-01-16

摘要

光纤激光深熔焊接羽辉可分为底部摆动羽辉和类似于激光束聚焦形态的狭长形羽辉. 采用6 kW的光纤激光焊接低碳钢,对比研究了旁轴高速保护气流对这两部分羽辉的影响. 结果表明,高速保护气流对狭长形羽辉具有明显的抑制效果,但其流向对焊接过程稳定性的影响则明显不同:气流逆焊接方向时飞溅多、熔深浅、焊缝成形差;气流沿焊接方向时飞溅少、熔深加深、焊缝成形良好,保护气流逆焊接方向时,小孔口前部凸起液柱发生偏折,小孔口缩小、熔池波动更剧烈. 进一步分析表明,保护气流逆焊接方向时,小孔口前部凸起液柱向小孔口偏折并堵塞小孔、影响底部摆动羽辉的喷发是致使焊接过程稳定性恶化的主要原因. 在光纤激光焊接中,布置保护气时应该考虑其流向对底部摆动羽辉喷发状态的影响.

本文引用格式

孔华 , 杨武雄 , 邹江林 , 赵振家 . 高速保护气流向对光纤激光深熔焊接羽辉的影响[J]. 焊接学报, 2023 , 44(8) : 14 -20 . DOI: 10.12073/j.hjxb.20220920001

Abstract

Plume is an inherent physical phenomenon in the process of fiber laser deep penetration welding. The plume consisted of two parts: the oscillating part at the bottom and has a serious negative impact on the laser welding process. At present, the removal method of narrow and long plume is mainly horizontal blowing with supersonic air curtain, but there is no targeted removal method for the swing part at the bottom. In this paper, 6 kW fiber laser is used to weld low carbon steel, and the influence of side shaft high-speed protective air flow on these two parts of plume is compared and studied. At the same time, the influence of protective airflow direction on the welding process was studied, the welding process was observed and the weld morphology was analyzed.

参考文献

[1] Saha P, Datta S, Raza M S, et al. Effects of heat input on weld-bead geometry, surface chemical composition, corrosion behavior and thermal properties of fiber laser-welded nitinol shape memory alloy[J]. Journal of Materials Engineering and Performance, 2019, 28(5): 2754-2763.
[2] Sharma L, Chhibber R. Study of weld bead chemical, microhardness & microstructural analysis using submerged arc welding fluxes for linepipe steel applications[J]. Ceramics International, 2020, 46(15): 24615-24653.
[3] Hao K, Wang H, Gao M, et al. Laser welding of AZ31B magnesium alloy with beam oscillation[J]. Journal of Materials Research and Technology, 2019, 8(3): 3044-3053.
[4] 赵乐, 曹政, 邹江林, 等. 高功率光纤激光深熔焊接匙孔的形貌特征[J]. 中国激光, 2020, 47(11): 1102005
Zhao Le, Cao Zheng, Zou Jianglin, et al. Keyhole morphological characteristics in high-power deep penetration fiber laser welding[J]. Chinese Journal of Lasers, 2020, 47(11): 1102005
[5] 徐国建, 李响, 杭争翔, 等. 光纤激光及CO2激光焊接高强钢[J]. 激光与光电子学进展, 2014, 51(3): 031403
Xu Guojian, Li Xiang, Hang Zhengxiang, et al. Laser welding of high strength steel using fiber laser and CO2 laser[J]. Laser & Optoelectronics Progress, 2014, 51(3): 031403
[6] 邹江林, 吴世凯, 肖荣诗, 等. 高功率光纤激光和CO2激光焊接熔化效率对比[J]. 中国激光, 2013, 40(8): 0803002
Zou Jianglin, Wu Shikai, Xiao Rongshi, et al. Comparison of melting efficiency in high power fiber laser and CO2 laser welding[J]. Chinese Journal of Lasers, 2013, 40(8): 0803002
[7] 张明军. 万瓦级光纤激光深熔焊接厚板金属蒸汽行为与缺陷控制[D]. 长沙: 湖南大学, 2013.
Zhang Mingjun. Study on the behavior of metallic vapor plume and defects control during deep penetration laser welding of thick plate using 10-kW level high power fiber laser [D]. Changsha: Hunan University, 2013.
[8] Li R, Wang T, Wang C, et al. A study of narrow gap laser welding for thick plates using the multi-layer and multi-pass method[J]. Optics & Laser Technology, 2014, 64: 172-183.
[9] Greses J, Hilton P A, Barlow C Y, et al. Plume attenuation under high power Nd: yttritium aluminum garnet laser welding[J]. Journal of Laser Applications, 2004, 16(1): 9-15.
[10] Zhang B, Dong Y, Du Y, et al. Microstructure and formability performance of fiber laser welded 1.2 GPa grade hot-rolled TRIP steel joints[J]. Optics & Laser Technology, 2021, 143(34): 107-341.
[11] Zhang C, Geng L, Ming G, et al. Microstructure and mechanical properties of narrow gap laser-arc hybrid welded 40 mm thick mild steel[J]. Materials, 2017, 10(2): 1-10.
[12] Zou J, Yang W, Wu S, et al. Effect of plume on weld penetration during high-power fiber laser welding[J]. Journal of Laser Applications, 2016, 28(2): 22-30.
[13] Zhang M, Zhang Z, Tang K, et al. Analysis of mechanisms of underfill in full penetration laser welding of thick stainless steel with a 10 kW fiber laser[J]. Optics & Laser Technology, 2018, 98: 97-105.
[14] 韩雪, 赵宇, 邹江林, 等. 基于可视化观察的光纤激光深熔焊接羽辉形成原因分析[J]. 中国激光, 2020, 47(6): 0602004
Han Xue, Zhao Yu, Zou Jianglin, et al. Analysis of plume formation in fiber laser deep penetration welding based on visual observation[J]. Chinese Journal of Lasers, 2020, 47(6): 0602004
[15] 邹江林, 李飞, 牛建强, 等. 高功率光纤激光焊接羽辉对焊接过程的影响[J]. 中国激光, 2014, 41(6): 0603005
Zou Jianglin, Li Fei, Niu Jianqiang, et al. Effect of laser-induced plume on welding process during high power fiber laser welding[J]. Chinese Journal of Lasers, 2014, 41(6): 0603005
[16] Zhao L, Tsukamoto S, Arakane G, et al. Prevention of porosity by oxygen addition in fibre laser and fibre laser–GMA hybrid welding[J]. Science & Technology of Welding & Joining, 2014, 19(2): 91-97.
[17] Schmidt L, Schricker K, Bergmann J P, et al. Effect of local gas flow in full penetration laser beam welding with high welding speeds[J]. Applied Sciences-Basel, 2020, 10(5): 1867.
[18] Cai Y, Heng H, Li F, et al. The influences of welding parameters on the metal vapor plume in fiber laser welding based on 3D reconstruction[J]. Optics & Laser Technology, 2018, 107: 1-7.
[19] Li M, Xiao R S, Zou J L, et al. A multiple synchronous imaging method for strong illuminants induced during a hot working process[J]. Laser Physics Letters, 2019, 16(6): 66003.
[20] 赵乐, 韩雪, 邹江林, 等. 光纤激光深熔焊接小孔形成过程的研究[J]. 激光与光电子学进展, 2020, 57(7): 227-233
Zhao Le, Han Xue, Zou Jianglin, et al. Research on formation process of keyhole during fiber laser deep penetration welding[J]. Laser & Optoelectronics Progress, 2020, 57(7): 227-233
[21] Li S C, Chen G, Zhang M J, et al. Dynamic keyhole profile during high-power deep-penetration laser welding[J]. Journal of Materials Processing Technology, 2014, 214(3): 565-570.
[22] Bao H T, Liu J H, Liu K, et al. Effect of vacuum laser welding process parameters on penetration depth of AZ31 magnesium alloy and defect analysis[J]. Applied Laser, 2008, 28(5): 5.
[23] Zou J L, Wu S K, He Y, et al. Distinct morphology of the keyhole wall during high-power fiber laser deep penetration welding[J]. Science and Technology Welding and Joining, 2015, 20(8): 655-658.
[24] 李明星, 胡治华, 陈铠. 保护气体种类对镀锌板激光焊接性的影响[J]. 激光杂志, 2006, 27(6): 72-73
Li Mingxing, Hu Zhihua, Chen Kai. The effect of shielding gas type on laser weld ability of galvanized stell[J]. Laser Journal, 2006, 27(6): 72-73
[25] Kaplan A F H, Powell J. Spatter in laser welding[J]. Journal of Laser Applications, 2011, 23(3): 3337-3344.
[26] Pellone L, Inamke G, Hong K M, et al. Effects of interface gap and shielding gas on the quality of alloy AA6061 fiber laser lap welding[J]. Journal of Materials Processing Technology, 2019, 268: 201-212.
[27] Konuk A R, Aarts R, Veld A, et al. Process control of stainless steel laser welding using an optical spectroscopic sensor[J]. Physics Procedia, 2011, 12(part-PA): 744-751.
[28] Wu D S, Hua X M, Huang L J, et al. Observation of the keyhole behavior, spatter, and keyhole-induced bubble formation in laser welding of a steel/glass sandwich[J]. Welding in the World, 2019, 63(3): 815-823.
[29] Zou J L, Ha N, Xiao R S, et al. Interaction between the laser beam and keyhole wall during high power fiber laser keyhole welding[J]. Optics Express, 2017, 25(15): 17650-17656.
[30] Fabbro R, Slimani S, Coste F, et al. Study of keyhole behaviour for full penetration Nd-Yag CW laser welding[J]. Journal of Physics D:Applied Physics, 2005, 38(12): 1881-1887.
[31] Li M, Xiao R S, Zou J L, et al. Correlation between plume fluctuation and keyhole dynamics during fiber laser keyhole welding[J]. Journal of Laser Applications, 2020, 32(2): 022010.
[32] Zou J, Han X, Zhao Y, et al. Investigation on plume formation during fiber laser keyhole welding based on in-situ measurement of particles in plume[J]. Journal of Manufacturing Processes, 2021, 65(15): 153-160.
[33] Zou J L, Wu S K, Yang W X, et al. A novel method for observing the micro-morphology of keyhole wall during high-power fiber laser welding[J]. Materials & Design, 2016, 89(5): 785-790.
[34] Zhang M J, Chen G Y, Zhou Y, et al. Observation of spatter formation mechanisms in high-power fiber laser welding of thick plate[J]. Applied Surface Science, 2013, 280(Complete): 868-875.
[35] Kawahito Y, Mizutani M, Katayama S. High quality welding of stainless steel with 10 kW high power fibre laser[J]. Science & Technology of Welding & Joining, 2009, 14(4): 288-294.
[36] Chang B H, Blackburn J, Allen C, et al. Studies on the spatter behaviour when welding AA5083 with a Yb-fibre laser[J]. The International Journal of Advanced Manufacturing Technology, 2016, 84: 1769-1776.
[37] Nakamura H, Kawahito Y, Nishimoto K, et al. Elucidation of melt flows and spatter formation mechanisms during high power laser welding of pure titanium[J]. Journal of Laser Applications, 2015, 27(3): 032012.
[38] Francisco C N, Milton P, Luiz E S P, et al. Effect of power modulation frequency on porosity formation in laser welding of SAE 1020 steels[J]. The International Journal of Advanced Manufacturing Technology, 2021, 112(9): 2509-2517.
[39] Zhang G L, Zhu B Q, Zou J L, et al. Correlation between the spatters and evaporation vapor on the front keyhole wall during fiber laser keyhole welding[J]. Journal of Materials Research and Technology, 2020, 9(6): 15143-15152.
文章导航

/